Dump Truck Repair
Concord, NC
Hydraulics, PTO, engine, brakes, transmission, dump body — CTR provides complete dump truck repair for all brands and configurations. 30+ years of severe-service experience.
Dump Truck Repair Experts
Dump trucks operate in the most demanding conditions in commercial trucking — heavy loads, rough terrain, constant cycling, dusty environments, and extreme temperatures. Every system on a dump truck works harder than its highway counterpart.
CTR understands the dump truck duty cycle. We service all brands and all configurations — single axle through quad-axle, super dumps, transfer dumps, belly dumps. Hydraulic systems, PTO, engine, transmission, brakes, suspension, dump body, and frame.
Located on Armentrout Drive directly off I-85 at Exit 58. All repairs backed by our 3-year, 36,000-mile warranty.
All Configurations
Single axle, tandem, tri-axle, quad, super dump, transfer, belly, side, and end dump.
Hydraulic Experts
Pump, cylinder, PTO, control valve — complete hydraulic system diagnosis and repair.
3-Year, 36K Warranty
Industry-leading warranty on all dump truck repairs. Parts and labor covered.
30+ Years
Three decades of severe-service dump truck repair experience.
Complete Dump Truck Repair Services
Every system on your dump truck — from hydraulics to frame. Click any service for details.
Complete dump truck hydraulic service — pump, cylinders, control valve, lines, fittings, and reservoir. Hydraulic pressure testing and flow analysis for accurate diagnosis.
Warning Signs of Dump Truck Problems
Dump Bed Won't Raise
Low hydraulic fluid, pump failure, PTO not engaging, or control valve stuck.
Bed Drifts Down Under Load
Hydraulic cylinder seal failure or control valve leak. Safety hazard.
Hydraulic Fluid Leaks
Line, fitting, cylinder, or pump seal failure. Causes environmental and safety issues.
PTO Won't Engage
Electrical issue, clutch pack wear, or transmission PTO output problem.
Overheating Under Load
Radiator plugging, fan clutch failure, or coolant system issue. Common in dusty conditions.
Brake Fade on Grades
Worn linings, glazed drums, or air system issue. Severe safety concern for loaded trucks.
Dump Truck Repair Cost Guide
| Service | Cost Range |
|---|---|
| Hydraulic Leak Repair | $300–$1,000 |
| PTO Repair | $500–$2,000 |
| Hydraulic Pump Replacement | $2,000–$5,000+ |
| Hydraulic Cylinder Rebuild | $800–$3,000 |
| Brake Overhaul (per axle) | $1,500–$3,500 |
| Dump Body Structural Repair | $500–$5,000+ |
| Engine Repair (sensor/component) | $500–$3,000 |
| Major Engine Work | $5,000–$15,000+ |
| Transmission Rebuild | $4,000–$10,000+ |
Written estimates provided before any work begins. All repairs backed by 3-year, 36,000-mile warranty.
Chassis Brands We Service
All Dump Truck Configurations
CTR services every dump truck configuration — from single-axle landscaping trucks to quad-axle super dumps. Each configuration has unique maintenance requirements based on its duty cycle, load capacity, and operating environment.
Single Axle
Landscaping, light construction
Tandem Axle
Standard construction hauling
Tri-Axle
Heavy aggregate hauling
Quad-Axle
Maximum payload capacity
Super Dump
Trailing axle for extra payload
Transfer Dump
Tractor and pup trailer
Belly Dump
Bottom-discharge trailers
Side Dump
Lateral discharge
End Dump
Standard rear discharge
Built for Heavy Duty
CTR's facility on Armentrout Drive has the equipment and bay space for complete dump truck service — from hydraulic cylinder rebuilds to major engine work. Directly off I-85 at Exit 58.
Fleet Dump Truck Maintenance
Programs designed for severe-service duty cycles — shortened PM intervals, oil and hydraulic fluid analysis, brake wear tracking, cooling system maintenance, PTO/hydraulic inspection at every PM, DOT scheduling, and fleet reporting.
(704) 786-0132
Dump Truck Repair Near You
CTR Heavy Duty — Concord
Directly off Interstate 85 at Exit 58. Easy truck access.
Also serving: